Gearbox noises
I have a noise from my gearbox (PK5) when I lift the clutch pedal in neutral whilst stationary. Sounds like a worn bearing noise to me - a little bit scrapy / clattery, or like marbles rolling around,...
View ArticleClik here to view.
Vivaro Maintenance and faults
Hey guys, Every month or so Ill take the air box off my vivaro and WD40 all the injectors ( JUST INCASE ) as we know they are buggers for getting stuck in, so yesterday i decided to take a few pictures...
View ArticleGoods in transit insurance
Hi, Does anyone have insurance to cover tools whilst in the van on a 24/7 basis (both at home and working away)? If so, who are you insured with and how much do you pay etc? Thanks in advance Sent ......
View Article1.9 vivaro not starting EML
Hello everyone, I have a 1.9 vivaro 2001 diesel and have had it for a little over a month. It never started right away always took about 2+ seconds even with a new battery. I removed the EGR valve to...
View ArticleClik here to view.
Air in the fuel line
Hi, back again I've got air in my fuel line and my van keeps cutting out. I disconnected the pipe near the engine and pumped all the air out and plugged it back in. It starts OK then cuts out again. I...
View ArticleGlow plug light and performance issue
Hi! My Vivaro 2.5 CDTI 2004 is suffering some strange performance issues. Like many of you, my van has also this poor acceleration and strugle to maintain speed when driving under 2500rpm. Like there...
View ArticleReverse camera wiring question
Just bought a reverse camera from ebay. This is the camera I have http://www.ebay.co.uk/itm/231558568622 I am fine on wiring the camera up to the reverse lights and routing the RCA cable to the front...
View ArticleRenault Master 2007 150dci limp mode
Hi all, after a bit of help or advice if possible. I've got a 2007 150dci Master - and I hope one of you might know what's causing my issue....... I get a reoccurring fault, where the van goes into...
View Article2007 150dci Master limp mode
Hi all, after a bit of help or advice if possible. I've got a 2007 150dci Master - I know it's not a tvp, but thought one of you lads might know what's causing my issue....... I get a reoccurring...
View ArticleCombo van clutch probs
I been getting a clutch pedal problem for a month now loses pressure and I have to pump pedal for a while to get pressure to build up then it's ok again for a few days but yesterday I had to pump for...
View ArticleHow to remove, replace, clean EGR 2.0 CDTI Vivaro, Trafic Primastar 2012 onwards
A how to for 2.0 cdti M9R-630, M9R-692 2012 onwards
View ArticleVivaro turbo problem!!!
Hi can anyone help, on the way home my turbo has started to make a very very loud noise sounds like the heaters are on full blast in the cab when I put my foot down, sounds to me as if one of the pipes...
View ArticleNew to the forum & looking for common faults / problems on 1.9 engines
Hi, I'm a newbie to the forum, so I wanted to say hi. I'm hoping to pick up a 2003 1.9 Vivaro Sportive which has covered 70k from its single owner (from new). It seems very clean, but trying to trawl...
View ArticleAux belt frayed, pieces in cambelt, help.
Hi all, this is my first post and I am in need of some advice. I have a 2006 Renault traffic, 1.9 dci van and unfortunately I have run into some serious trouble. Basically I was driving around 20mph...
View ArticleVivaro nightmare finally sorted!
Hello Everyone! Probably a long post, but I thought I'd put it on to try and help anyone else out who's having similar issues. I bought a 2006 vivaro for my plumbing business. It drove like a car and...
View Article2.0L CDTi M9r 780 - misfire / open circuit fault test
Hi all, found this re this engine fault so thought i'd share as it may help some peeps out. And it also relates to my previous water leak fixes thread. "Quote" As many of you know the 2.0 CDTI M9R780...
View ArticleLED interior light bulbs (lamps)
Have you fitted LED bulbs (lamps) to the existing interior lights in the cab / back? If so, we're there any issues as I know on some makes & models (I.e. Seat Ibiza) this can cause a problem with...
View ArticleCoolng System Problem...
Guys, Looking for some advice again… I had to get a couple of coolant hoses replaced the past couple of weeks following 2 separate leaks, the first was hose was some triple hose type that had split,...
View ArticleWatchdog Vivaro / Trafic / Primastar Injector faults/issues/problems
Hi fellow members , i have just spotted on the tv listings that the BBC Watchdog consumer programme is doing a big number on the problems with injector ceasing and bad wiring in the Vivaro / traffic /...
View ArticleSouth Wales....
Could anyone recommend a garage or a member that is a vivaro guru in Newport or Cardiff by any chance? Thanks
View Article